酶脱支处理对颗粒态缓慢消化淀粉形成的影响

详细信息    查看全文 | 推荐本文 |

英文篇名：Effect of Enzyme Debranching Treatment on Formation of Granular Slowly Digestible Starch 作者：赵凯 ; 陈威 ; 宫玉晶 ; 刘宁 ; 陈凤莲 ; 杨春华 英文作者：ZHAO Kai;CHEN Wei;GONG Yujing;LIU Ning;CHEN Fenglian;YANG Chunhua;Provincial Key Laboratory for Food Science and Engineering, Harbin University of Commerce; 关键词：玉米淀粉 ; 酶脱支处理 ; 缓慢消化淀粉 ; 颗粒态 ; 直链淀粉 ; 溶出 英文关键词：corn starch;;debranching treatment;;slowly digestible starch;;granular state;;amylose;;leaching 中文刊名：BQGB 英文刊名：Journal of Food Science and Technology 机构：哈尔滨商业大学食品科学与工程省级重点实验室; 出版日期：2019-02-19 09:27 出版单位：食品科学技术学报 年：2019 期：v.37;No.148 基金：哈尔滨市科技创新人才项目(2014RFXXJ068);; 哈尔滨商业大学校内科研项目(18XN075) 语种：中文; 页：BQGB201902007 页数：6 CN：02 ISSN：10-1151/TS 分类号：46-51

摘要

以玉米淀粉为原料,研究了低于淀粉糊化温度条件下酶脱支处理对直链淀粉溶出及缓慢消化淀粉形成的影响。选取不同条件产物,采用Guraya法测定酶脱支处理后的缓慢消化淀粉含量的变化,从而研究酶脱支处理过程上清液中溶出的直链淀粉与沉淀淀粉颗粒态缓慢消化淀粉含量之间的关系。并利用扫描电子显微镜、X-射线衍射仪、差示扫描量热仪等进一步研究酶脱支淀粉的颗粒形貌、结晶特性、热焓特性。结果表明,直链淀粉溶出量与缓慢消化淀粉形成具有相关性;低于糊化温度下通过酶脱支制备缓慢消化淀粉能提高淀粉颗粒表面的疏松度;相对于结晶的数量,结晶的质量对淀粉消化性影响更大;酶脱支处理后,淀粉糊化的起始温度、峰值温度、终止温度均有所增加,糊化温度区间变小,糊化焓降低。
        Using corn starch as raw material, the effect of debranching treatment on amylose leaching and formation of slowly digestible starch was studied below gelatinization temperature. Based on Guraya method, the SDS contents under various conditions were determined. A correlation between amylose leaching and SDS content was established. The granule morphology, crystallization properties, and thermal properties of starches were carried out through scanning electron microscope, X-ray diffraction, and differential scanning calorimetry. The results showed that amylose leaching was associated with SDS formation. The looseness of the starch surface was improved after debranching treatment below the gelatinization temperature while the crystal quality had greater influence on the formation of SDS compared with quantity. After debranching treatment onset temperature, peak temperature, and conclusion temperature of the corn starch increased, while gelatinization temperature range and enthalpy change decreased.

引文

[1] ENGLYST H N,KINGMAN S M,CUMMINGS J H. Classification and measurement of nutritionally important starch fractions[J]. European Journal of Clinical Nutrition, 1992, 46(s2): 33-50.
    [2] LEHMANN U,ROBIN F. Slowly digestible starch-its structure and health implications: a review[J]. Trends in Food Science & Technology, 2007, 18(7): 346-355.
    [3] 黄峻榕,任瑞珍,蒲华寅,等.慢消化淀粉的消化特性、测定及制备[J].中国粮油学报,2015,30(3):134-139. HUANG J R,REN R Z,PU H Y,et al.Digestion characteristics determination and preparation of slow-digested starch[J].Journal of the Chinese Cereals and Oils Association,2015,30(3):134-139.
    [4] 赵凯,李君,谷广烨.酶脱支处理对玉米缓慢消化淀粉形成的影响[J].食品科学,2017,38(1):177-181. ZHAO K,LI J,GU G Y.Effect of debranching treatment on the formation of slowly digestible corn starch[J].Food Science,2017,38(1):177-181.
    [5] LEE C J,MOON T W. Structural characteristics of slowly digestible starch and resistant starch isolated from heat-moisture treated waxy potato starch[J]. Carbohydrate Polymers, 2015, 125: 200-205.
    [6] LEE C J,KIM Y,CHOI S J,et al. Slowly digestible starch from heat-moisture treated waxy potato starch: preparation, structural characteristics, and glucose response in mice[J]. Food Chemistry, 2012, 133(4): 1222-1229.
    [7] ZHANG L L,HU X T,XU X E,et al. Slowly digestible starch prepared from rice starches by temperature-cycled retrogradation[J]. Carbohydrate Polymers, 2011, 84(3): 970-974.
    [8] LI X L,WANG Y J,LEE B H,et al. Reducing digestibility and viscoelasticity of oat starch after hydrolysis by pullulanase from Bacillus acidopullulyticus[J]. Food Hydrocolloids, 2018, 75: 88-94.
    [9] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会. 大米直链淀粉含量的测定: GB/T 15683—2008[S].北京:中国标准出版社,2009.
    [10] GURAYA H S,JAMES C,CHAMPAGNE E T. Effect of enzyme concentration and storage temperature on the formation of slowly digestible starch from cooked debranched rice starch[J]. Starch-Starke, 2001, 53(3/4): 131-139.
    [11] 赵凯,谷广烨.缓慢消化淀粉测定过程中的影响因素分析[J].食品科学,2009,30(14):197-199. ZHAO K,GU G Y.Factors affecting the determination of slowly digestible starch by the Guraya method[J].Food Science,2009,30(14):197-199.
    [12] LI L J,HONG Y,GU Z B,et al. Effect of a dual modification by hydroxypropylation and acid hydrolysis on the structure and rheological properties of potato starch[J]. Food Hydrocolloids, 2018, 77: 825-833.
    [13] YANG C H, BELAMKAR V, CANNON S B, et al. Characterization and development mechanism of Apios americana tuber starch[J]. Carbohydrate Polymers, 2016, 151: 198-205.
    [14] HOOVER R,HADZIYEV D. Characterization of potato starch and its monoglyceride complexes[J]. Starch-Starke, 1981, 33(9): 290-300.
    [15] TESTER R F,KARKALAS J,QI X. Starch-composition, fine structure and architecture[J]. Journal of Cereal Science, 2004, 39(2): 151-165.
    [16] HOOVER R,VASANTHAN T. The effect of annealing on the physicochemical properties of wheat, oat, potato and lentil starches[J]. Journal of Food Biochemistry, 1994, 17(5): 303-325.
    [17] CHUNG H J,LIU Q,HOOVER R. Impact of annealing and heat-moisture treatment on rapidly digestible, slowly digestible and resistant starch levels in native and gelatinized corn, pea and lentil starches[J]. Carbohydrate Polymers, 2009, 75(3): 436-447.