活性炭与RO膜联合处理低放废水影响因素研究

详细信息    查看全文 | 推荐本文 |

英文篇名：Study on influencing factors of activated carbon and reverse osmosis membrane combined treatment of low-level radioactive wastewater 作者：辜润秋 ; 左天明 ; 祝长生 ; 赖万昌 ; 张耀奎 ; 刘冬 ; 徐义仁 英文作者：GU Runqiu;ZUO Tianming;ZHU Changsheng;LAI Wanchang;ZHANG Yaokui;LIU Dong;XU Yiren;Sichuan Radiation Detection & Protection Institute of Nuclear Industry;Chengdu University of Technology; 关键词：活性炭 ; RO膜 ; 吸附 ; 低放废水 ; 影响因素 英文关键词：activated carbon;;reverse osmosis membrane;;adsorption;;low-level radioactive wastewater;;influencing factors 中文刊名：膜科学与技术 英文刊名：Membrane Science and Technology 机构：四川省核工业辐射测试防护院;成都理工大学; 出版日期：2019-04-25 出版单位：膜科学与技术 年：2019 期：02 语种：中文; 页：71-76+91 页数：7 CN：62-1049/TB ISSN：1007-8924 分类号：X771;TQ028.8

摘要

随着核技术在各行业的广泛应用,低放射性废水的产生量逐渐增多,然而目前大多数放射性废水传统的处理方法均存在各自的缺点.因此,采用活性炭与反渗透(RO)膜联合处理低放射性废水不仅可以提高放射性核素的去除效率,而且能降低经济成本.选取多种材质的活性炭作对比,通过实验获得原始废液与活性炭的最佳单位体积质量比、活性炭与废液两相接触的最佳时间以及活性炭吸附与RO膜处理的原始废液的最优pH范围.结果表明,木质、椰壳以及炭质3种活性炭中木质活性炭对放射性核素的吸附效果最佳,其与废液最佳的单位体积质量比为250 g/L,木质活性炭与RO膜联合处理方法的最佳废水原液pH范围均为0～1,活性炭与废水两相接触最佳时间为1 h左右.木质活性炭与RO膜在最佳的条件下联合处理低放射性废水,所得结果中的U、Th、总α以及总β的去除率分别为95.27%、99.61%、99.89%、99.41%.
        With the wide application of nuclear technology in various industries, the production of low-level radioactive wastewater is increasing. However, most of the traditional treatment of radioactive wastewater have their own shortcomings. But the way of combining the activated carbon with reverse osmosis(RO) membrane not only improves the removal efficiency of radionuclides but also reduces economic costs. Firstly, different materials of activated carbon are selected for comparison. Through experiments, the best unit volume-to-mass ratio of raw waste liquid to activated carbon, the best time for two-phase contact between activated carbon and waste liquid, and the best pH range of raw waste liquid adsorbed by activated carbon and reverse osmosis membrane are obtained. The results showed that among the three kinds of activated carbon, wood, coconut shell and carbon, wood-based activated carbon had thebest adsorption effect on radionuclides. The best unit volume mass ratio of wood-based activated carbon to waste liquid was 250 g/L, the best pH range of wastewater stock solution was 0～1 for wood-based activated carbon and reverse osmosis membrane, and the best time for two-phase contact between activated carbon and waste water was about 1 h. The removal rates of U, Th, total α and total β in the combined treatment of low-level radioactive wastewater with wood activated carbon and reverse osmosis membrane were 95.27%, 99.61%, 99.89% and 99.41% respectively.

引文

[1] 王建龙,刘海洋.放射性废水的膜处理技术研究进展[J].环境科学学报,2015,33(10):2639-2656.
    [2] 黄瑶瑶,黄涵芳,石润平.放射性废水处理技术研究进展[J].应用化工,2018,47(1):185-189.
    [3] Hill C,Dozol J F,Lamare V,et al.Nuclear waste treatment by means of supported liquid membranes containing calixcrown compounds[J].J Inclusion Phenom Macrocycl Chem,1994,19(1/4):399-408.
    [4] Valsala T P,Sonavane M S,Kore S G,et al.Treatment of low level radioactive liquid waste containing appreciable concentration of TBP degraded products[J].J Hazard Mater,2011,196(12):22-28.
    [5] Ahmadpour A,Zabihi M,Tahmasbi M,et al.Effect of adsorbents and chemical treatments on the removal of strontium from aqueous solutions[J].J Hazard Mater,2010,182(1):552-556.
    [6] 顾忠茂.核废物处理技术[M]//北京:原子能出版社,2009.
    [7] 何佳恒,蹇源,李兴亮.无机离子交换材料在放射性废水处理中的应用[J].辐射防护通讯,2009,28(6):9-13.
    [8] 周书葵,娄涛,庞朝晖.放射性废水处理技术[M]//北京:化学工业出版社,2011.
    [9] 李小燕,张叶.放射性废水处理技术研究进展[J].铀矿冶,2010,29(3):153-156.
    [10] 梁霞,王学江.活性炭改性方法及其在水处理中的应用[J].水处理技术,2011,37(8):1-6.
    [11] 陈利芳,陆晓峰,卞晓锴.纳滤法去除模拟放射性废水中Sr2+的研究[J].膜科学与技术,2014,34(5):44-48.
    [12] 王建龙,刘海洋.放射性废水的膜处理技术研究进展[J].环境科学学报,2015,33(10):2639-2656.
    [13] 孔劲松,郭卫群.反渗透技术在放射性废水处理中的应用进展[J].核动力工程,2012,33(3)121-124.
    [14] 乐志东.中低放废液反渗透处理数学模型研究及验证[D]//上海:上海交通大学,2014.
    [15] 刘群芳.活性炭吸附矿山废水中放射性核素研究[J].铀矿冶,2016,35(8):219-223.