Ash Particulate Formation from Pulverized Coal under Oxy-Fuel Combustion Conditions
详细信息 查看全文
- 作者：Yunlu Jia ; JoAnn S. Lighty
- 刊名：Environmental Science & Technology (ES&T)
- 出版年：2012
- 出版时间：May 1, 2012
- 年：2012
- 卷：46
- 期：9
- 页码：5214-5221
- 全文大小：499K
- 年卷期：v.46,no.9(May 1, 2012)
- ISSN：1520-5851
文摘
Aerosol particulates are generated by coal combustion. The amount and properties of aerosol particulates, specifically size distribution and composition, can be affected by combustion conditions. Understanding the formation of these particles is important for predicting emissions and understanding potential deposition. Oxy-fuel combustion conditions utilize an oxygen-enriched gas environment with CO2. The high concentration of CO2 is a result of recycle flue gas which is used to maintain temperature. A hypothesis is that high CO2 concentration reduces the vaporization of refractory oxides from combustion. A high-temperature drop-tube furnace was used under different oxygen concentrations and CO2 versus N2 to study the effects of furnace temperature, coal type, and gas phase conditions on particulate formation. A scanning mobility particle sizer (SMPS) and aerodynamic particle sizer (APS) were utilized for particle size distributions ranging from 14.3 nm to 20 渭m. In addition, particles were collected on a Berner low pressure impactor (BLPI) for elemental analysis using scanning electron microscopy and energy dispersive spectroscopy. Three particle size modes were seen: ultrafine (below 0.1 渭m), fine (0.1 to 1.0 渭m), and coarse (above 1 渭m). Ultrafine mass concentrations were directly related to estimated particle temperature, increasing with increasing temperature. For high silicon and calcium coals, Utah Skyline and PRB, there was a secondary effect due to CO2 and the hypothesized reaction. Illinois #6, a high sulfur coal, had the highest amount of ultrafine mass and most of the sulfur was concentrated in the ultrafine and fine modes. Fine and coarse mode mass concentrations did not show a temperature or CO2 relationship. (The table of contents graphic and abstract graphic are adapted from ref 27.)