摘要
采用直接熔解法研究了SiO_2颗粒在CaO-SiO_2-MgO-Al_2O_3渣系中的熔解过程,探索了炉渣成分、温度对SiO_2颗粒熔解时间的影响规律,通过SEM-EDS并结合factsage软件分析了SiO_2熔解机理,确定SiO_2颗粒周围没有形成固相层,并在此基础上结合缩芯模型构建了动力学模型。结果表明,随着炉渣碱度及温度提高,SiO_2颗粒熔解完成所需时间逐渐降低,而随着炉渣中MgO及Al_2O_3含量增加,SiO_2颗粒的熔解完成所需时间先降低后增加。SiO_2的熔解过程分为2个阶段,反应前期为界面反应控制,表观活化能为330.52 k J/mol;反应后期为外扩散控制,表观活化能为480.28 k J/mol,控制环节的转变是由熔体黏度的变化造成的。
The melting process of SiO_2 particles in CaO-SiO_2-MgO-Al_2O_3 system was studied by using direct melting method,and effects of furnace slag compositions,temperature on the SiO_2 particles melting time were investigated. The melting mechanism of SiO_2 particles was analyzed by using SEM-EDS and factsage software. It is found that there was no solid-phase layer formed around SiO_2 particles.On this basis,a kinetic model was constructed by combining with the shrinking core model. Results show that the melting time of SiO_2 particles in slag shortened with the rising of slag basicity and temperature,while the increased content of MgO and Al_2O_3 in slag led to the melting time of SiO_2 particles prolonged after initially shortened. It is shown that the melting process of SiO_2 is divided into two stages: an earlier stage is controlled by a surface reaction,with an apparent activation energy of 330. 52 k J/mol,and the later stage is controlled by an external diffusion with an apparent activation energy of 480. 28 k J/mol. And such transition is mainly caused by the variation in the melt viscosity.
引文
[1]肖永力,李永谦,刘茵,等.高炉渣矿棉的研究现状及发展趋势[J].硅酸盐通报,2014,3(7):1689-1694.
[2]Yabuta K,Tozawa H,Takahashi T.New applications of iron and steelmaking slag contributing to a recycling-oriented society[J].JFE Giho,2004(6):24-29.
[3]张升晓,岳钦艳,于慧,等.高炉渣制备微晶玻璃的研究[J].山东大学学报,2006,41(5):129-133.
[4]郝洪顺,徐利华,张作顺,等.高炉矿渣二次资源合成绿色无机材料的研究进展[J].材料导报,2010,24(11):97-100.
[5]Nobuhiro Maruoka,Akira Ishikawa,Hiroyuki Shibata,et al.Dissolution rate of various limes into steelmaking slag[J].High Temp Mater Proc,2013,32(1):15-24.
[6]Tasuku Hamano,Shinya Fukagai,Fumitaka Tsukihashi.Reaction mechanism between solid Ca O and Fe Ox-Ca O-Si O2-P2O5slag at1 573K[J].ISIJ International,2006,46(4):490-495.
[7]Liu J,Guo M,Jones P T,et al.In situ observation of the direct and indirect dissolution of Mg O particles in Ca O-Al2O3-Si O2-based slags[J].Journal of the European Ceramic Society,2007(27):1961-1972.
[8]Shaowei Zhang,Hamid Reza Rezaie,Hossain Sarpoolaky,et al.Alumina dissolution into silicate slag[J].J Am Ceram Soc,2000,83(4):897-903.
[9]Yu B,Lv X,Xiang S,et al.Dissolution kinetics of Si O2into Ca OFe2O3-Si O2slag[J].Metallurgical&Materials Transactions B,2016,47(3):2063-2071.
[10]孙彩娇,张玉柱,李杰,等.碱度对高炉熔渣制备矿渣棉调质剂性能的影响[J].钢铁钒钛,2017,38(2):81-86.
[11]杨润德,侯晓川,李贺.Mg O含量对高炉渣性质影响的理论解析[J].矿冶工程,2014,34(6):60-64.
[12]贺实月,李会泉,李少鹏,等.煤粉炉高铝粉煤灰碱溶脱硅反应动力学[J].中国有色金属学报,2014,24(7):1888-1894.
[13]Breed A W,Hansford G S.Studies on the mechanism and kinetics of bioleaching[J].Minemls Engineering,1999,12(4):383-392.
[14]吴铿,折媛,朱利,等.对建立冶金反应工程学科体系的思考[J].钢铁研究学报,2014,26(12):1-8.