摘要
本研究采用 Fenton 试剂、超声波和催化电解法处理生化处理后的垃圾渗滤
液(称原水)。原水 COD、BOD、氨氮、氯离子浓度和色度分别为 789~1602mg/L、
29.7~100mg/L、411~538.7 mg/L 、1542.8~1923 mg/L 和 1095~2520 倍。
采用 Fenton 试剂处理生化处理后的垃圾渗滤液。在初始 pH 为 4,FeSO4·7H2O
投加量为 15mmol/L,H2O2/ FeSO4·7H2O 的投加比控制为 4:1,H2O2投加次数为 1
次,反应时间为 20 分钟,反应后调节 pH 为 8.0 的反应条件下,COD 从 1103 mg/L
降到 284mg/L,COD 去除率为 69.11%;出水色度为 44,色度去除率为 97.82%。
Fenton 氧化机理主要是羟基自由基氧化和铁离子混凝的共同作用,使废水中的
有机物被去除。fenton 试剂对水中氨氮没有去除作用。
采用低频率超声波处理生化处理后的垃圾渗滤液。初始 pH 为 11, 超声功
率为 1250W/L,反应时间为 30 分钟,出水 COD 为 728mg/L,COD 去除率为 19.2%;
出水氨氮为 240mg/L,氨氮去除率为 50.3%。低频率超声处理对氨氮去除效果较
好,对 COD 的去除作用不大。
采用催化电解法处理生化处理后的垃圾渗滤液。采用镀钌/铑/镐稀土金属的
钛网阳极板(DSA),电极板上的稀土金属具有催化电解作用。 3cm 的极板间距,
在初始 pH 为 8,催化电解电流密度为 8A/dm2的条件下,电解 120 分钟后,氨氮
的去除率是 100%;出水 COD 浓度为 652 mg/L,去除率为 44.9%。
采用 Fenton 试剂-电解联合处理生化处理后的垃圾渗滤液。当电解电流为
8A/dm2时,pH=10,电解 120 分钟,COD 从 248mg/l 降低到 93.5 mg/L,COD 去除
率为 62.3%,氨氮从 443mg/l 降低到 0 mg/L,氨氮的去除率为 100%。
对比各种氧化方法,Fenton 试剂对 COD 的去除效果最好,而催化电解对氨氮
去除效果最好。处理渗滤液时,可选用 Fenton 试剂-电解联合处理工艺,能够较
好的处理效果。
The Fenton’s reagent ,sonication and electrochemical treatment are used in this
thesis to treat the effluent discharged from biological treatment process of landfill
leacheat. COD,BOD ,ammonia nitrogen,Cl- and chroma concentration in the
effluent were 789~1602 mg/L、29.7~100mg/L 、411~538.7 mg/L 、1542.8~1923
mg/L and 1095~2520 times.
The purpose of this experiment is to operate Fenton oxidation process efficiently.
The organic was oxidized with the ?OH free racial and coagulated by Fe3+ ions,
which were provided by Fenton’s reagent . The total COD and chroma removal of the
leachate by Fenton oxidation is over 69%、97.82%and COD and chroma value of the
effluent can be 284mg/L、44 times under the following oxidation conditions:reaction:
20min reaction time, 15mmol/L FeSO4·7H2O, the H2O2/ FeSO4·7H2O ratio of 4
to 1,the optimum pH of 4 for the Fenton oxidation process and 8.0 for the coagulation
process. Unfortunately ,the Fenton’s reagent can not remove NH3-N .
The sonicatial treatability of landfill leachate has been investigated in this paper.
After ultrasonic 30min in a frequency of 20KHz , the residul COD is 728mg/L and the
COD removal rate is 19.2% with the optimum reaction conditions where are pH=11
and sonication strength of 1250W/L . The ammonia nitrogen removal rate and the
ammonia nitrogen concentration in the outlet are 50.3% and 240mg/L,respectively.
COD removal of landfill leachate is not good enough in low frequency
ultrasonication.
A ternary Rh-Zr-Ru oxide-coated titanium(DSA) anode fixed in a lab-scale
electrolysis reactor was used to treat landdfill leachate in this investigation. The
lanthanons on the special ternary anode have electrolysis oxidation catalysis Under
the operating conditions of 8A/dm2 current density 、3cm electrode gap and the
optimum pH of 8, 100% of the ammonia nitrogen in the leachate was removed after
electrolysing for 120min. At the same time ,the COD removal rate is 44.9% and the
COD in the effluent is 652mg/L.
Combined Fenton’s reagent and electrochmical process is also used to treat the
landfill leachate in this paper .After reaction 120min ,the COD and ammonia
concentration were down to 93.5 mg/L and 0 mg/L while the removal rate COD and
ammonia nitrogen were 62.3% and 100%, respectively.
In the experiments,the Fenton’s reagent is the best process to remove the COD in
the leachate ,while the best process for removing ammonia nitrogen is electrochmical
process. So the best treatment process for the leachate is combined Fenton’s reagent
and electrochmical process, which can make landfill leacheat to meet the national
discharge standard 。
引文
1. 范家明,等,广州大田山垃圾填埋场渗滤液污染现状的调查,环境卫生工
程,2001, 9(4):160-162
2. 康瑛,等,垃圾填埋城镇扬渗滤陡量合新众处理初,探浙江水利科
技,2001,9(4):11-12
3. 吴晨,等,城市垃圾渗滤液处理技术,给水排水,1996,22(5):11-12
4.陶涛,等,垃圾填埋场渗滤液处理研究,武汉城市建设学院学报,1998,15
(3):58-62
5. 邹莲花,等,城市生活垃圾填埋场渗滤液水质影响因素分析及水质预测,
给水排水,1997,23(7):57-60
6. Zolten,N.G., Leachate Treatment in landfill , Water
Environmant & Technology,1991,3(5):61-66
7.D.Geenens, Combined ozone-actived sludge treatment of landfill
leachate, Water Science and Technology,1999, 44(2-3):359-365
8.Martin, Craig D., Performance of a Constructed Wetland Leachate
Treatment System at the Chunchula Landfill, Mobile County, Alabama, Water
Science and Technology, 1999, 40(3): 67-74
9. 周吉林,垃圾填埋场渗滤水的处理技术,环境污染与防治,2001,23(4):
187-189
10.杨霞,等,城市生活垃圾填埋场渗滤液处理工艺研究,环境工程,2000,18
(5):12-14
11. N.Paxeus, Organic compounds in municipal landfill leachates,Water
Science and Technology, 2000, 42(7):323-333
12. 薛军,处理城市垃圾填埋场渗滤液的新工艺,中国环保产业,2001
13.Welander, U., Biological nitrogen removal from municipal landfill
leachate in a pilot scale suspended carrier biofilm process, Water
Research, 1998, 32(5): 1564-1570
14. 刘叔俊,垃圾渗滤液污染处理的现状和对策,武汉建设,2001,37(3):
36-37
15. 赵新泽,垃圾填埋场渗滤液的处理研究发展,三峡大学学报,2002,12
(1):83-87
16. 吴建平,浅谈卫生垃圾填埋场渗滤液的处理,环境卫生工程,2001,9(2):
77-79
- 80 -
参考文献
17. B.Inanc, Characterization and anaerobic treatment of the sanitary
landfill leachate in Istanbul,2000,41(3):223-230
18. Pohland, F. G. In Situ Anaerobic Treatment of Leachate in Landfill
Bioreactors, Water Science and Technology, 1999, 40(8): 203-210
19.沈耀良,等,厌氧折流板反应器处理垃圾渗滤混合废水,中国给水排
水.1999,15(5):10-12
20.贺延龄,废水的厌氧生物处理,中国轻工业出版社,1998
21. 王宝贞,等,水解酸化--好氧工艺处理渗滤液与城市污水混合废水的研
究,哈尔滨建筑大学学报,1999,32(1):57-61
22.李征,UASB-MBAC 工艺处理城市垃圾填埋厂渗滤液试验研究,天津大学硕
士论文,2002,10
23. 赵宗升,等,A2/O 与混凝沉淀法处理垃圾渗滤液研究,中国给水排
水,2001,17(11):13-16
24. 熊忠,等,混凝—Fenton—SBR 处理垃圾渗滤液的影响因素研究,城市环
境,2002,16(4):19-21
25.张自杰,排水工程(下册),第三版,中国建筑工业出版社,1999,6.
26. 于瑞莲,等,用天然膨润土预处理垃圾渗滤波的实验研究,福建化
工,2002,3:7-10
27. 隋智慧,等,物理化学法处理垃圾填埋场渗滤液的研究进展,环境污染治
理技术与设备.2002,3(4): 43-46
28. 沈耀良 , 等 , 垃圾渗滤液的混凝一吸附预处理研究 , 中国给水排
水,1999,15(11):11-15
29. 张晖,等,Fenton 法处理垃圾渗滤液,中国给水排水,2001,17(3):1-3
30.王鹏,等,垃圾渗滤液中难降解有机物的 Fenton 混凝处理,应用化
学,2001,18(5):408-411
31. J.Yoon,The characterritics of coagulation of Fenton reaction in
the removal of landfill leachate
organics,Wat.Sci.Tech,1998,vol38(2):209-214
32. S.-H.Gau,Improve Fenton method to remove recalcitrant organics
in landfill leachate, Wat.Sci.Tech,1996,vol34(7-8):445-462
33.孟玢,垃圾渗滤液生化工艺出水的深度处理试验研究,天津大学硕士论
文,2003,5
34.张乐, 吹脱法处理垃圾渗滤液中氨氮的实验研究,天津大学本科毕业论
文,2003,7
35. 王琳, 深度氧化技术(AOTs)及其在污水处理中的应用污染防治技
术.1998,11(1):25-27
- 81 -
参考文献
36. 袁维芳 , 等 , 反渗透法处理城市垃圾填埋场渗滤液 , 水 处 理 技
术,1997,23(6): 333-336
37. Li-CHoung Chiang et al Indiect oxidation effect in electrochemical
oxidation treatment of landfill leachate,1995,Wat .Res vol.29:671-678
38. 《水质分析方法国家标准汇编》1996
39. 包文滁,等,工业“三废”的治理[M],河北人民出版社,1979,58-113
40. 陈传好,等,Fenton 试剂处理废水中各影响因素的作用机制,环境科
学,2000,21(3):93-96
41. 刘冬莲,·OH 的形成机理及在水处理中的应用,环境科学与技术,2003,26
(1):44-46
42. 桥 本 和 仁 , 等 ,Titannium Dioxide;New Uses Through
Nano-Technology[J].NATURE,1997,88(3):431-432
43. 刘勇第,等, 几种类 Fenton 试剂的氧化特性及在工业废水处理中的应用,
上海环境科学,1994,13(3):26-34
44. Yoon,J.,The characteristics of fenton reaction in the removal
of landfill leachate organics,Water Science and Technology ,1998,38
(2):20-214
45. 王罗春,等,Fenton 试剂处理难降解有机废水及其应用,环境保护科
学,2001,27(6):11-14
46. 李燕城,水处理实验技术,中国建筑工业出版社,1997:186-191
47. 王罗春,Fenton 试剂处理电厂离子交换树脂再生废水,环境污染与防
治,2001,23(5):238-240
48. 高迎新,等,Fenton 反应中水解 Fe(III)的形态分布特征研究,环境科
学学报,2002,22(5):551-556
49. 程洁红,等,Fenton-混凝法在垃圾渗滤液预处理中的试验研究,江苏石
油化工学院学报,2002,14(2):27-29
50. Buxton G V,Greenstock C L,Helman W P ,et al.J Phys Chem Ref
Dat ,1999,17:513
51. 肖羽堂,等,Fenton 试剂预处理 H 酸废水的影响因素及其可生化性,环境
化学,2001,20(3):281-285
52. J.Fetting,Treatment of landfill leachate by preozonation and
adsoption in actived carbon columns, Water Science and
Technology ,1996,34(9):30-40
53. 许保久,当代给水与废水处理原理讲义,清华大学出版社,1983: 153 -
159
- 82 -
参考文献
54. (Luciana,Application of Fenton’s reagent to trgenerate activated
carbon saturated with organochloro
compounds,Chemosphere,2003,vol5:1049-1054)
55.王鹏,等,垃圾渗滤液中难降解有机物的 Fenton 混凝处理,应用化
学,2001,18(5):408-411
56.卞华松,等,中和混凝与催化氧化法处理高浓度有机废水,上海环境科
学,2002,21(4):244-246
57. 孙德智,等,环境工程中的高级氧化技术,2002,4:295-297
58. 王建龙,等,声化学在水污染控制中的应用研究现状,化学通报,1997,7:
35—38
59. 李春喜,等,超声波技术在污水处理中的应用与研究进展,环境污染治理
技术与设备,2001,2(2):64-69)
60. 傅敏,等超声波降解苯胺溶液的实验研究,环境科学学报,2002,22(3):
402-404
61. 林奇,吹脱法处理中低浓度氨氮废水[J],福建环境,2000,17(6): 35—
37
62. Inex Hua,Ualf H Hocherner,Miochael R Hoffmenu.Sonolytic
hydrolysis ofpaitrop Henyl acefate:The role of supercritical water.[J]
Phys,Chem,1995,99:2335-2342
63. 冯若,等,声化学及其应用[M],合肥:安徽科技出版社,1992,229-238
64. 程存,第,超声技术—功率超声及其应用[M],西安:陕西师范大学,
1993.208-229
65. H Michael Cheung,Ashish Bhatnagear,Greg Jansen,Sonochemical
ditruction of chlorinated hydrocarbons in aqueous solution [J].Environ.
Sci & Technol,1991,25:1310-1512
66 Okoucbi S,Nojima O, Cavitation 一 induced degradation of phenol by
ultrasound Water Sci Technol [C],1992 26(9—11 Water Qual Int’92 Pt 5)2053—
2056.
67 Petrize Christian,Micolle Marc, Characterstics of pintachlorophenater
degradation [J]. Envir Sci Technol ,1992,26(8):1639—42
68. 刘俊梁,等,电解法处理染料生产废水技术研究,河北建筑科技学院学
报,1998,15(3):63-66
69.季尚捡,等,印染废水三维电解法脱色试验研究,青岛建筑工程学院学
报,2000,21(2):35-38
70. 赵国华,等,苯酚溶液电解降解的过程分析及中间体的研究, 同济大学
学报,2000,28(5):
71.冯玉杰,等,电化学技术在环境工程中的应用,化学工业出版社,2002,5
- 83 -
参考文献
72.王敏,催化电解法处理垃圾渗滤液的研究,环境科学与技术,2002,25(2):
17-19
73.唐受印,废水处理工程,化学工业出版社,2000,5
74. Antropov L .Theroritical electrochemical .1st ed .Mosow:Mir
Publishers ,1977
75. A.G.Vlyssides,Testing an electrochemical method for treatment of
textile dye wastewater,Waste Management ,2000,vol 20:569-574
76. Murphy O.J et al Direct electrochemical oxidation of organics for
wastewater treatment. Wat.Res.1992.26,443-289
77. Marincic et al.Electro-oxidation of ammonia in wastewater .J
appl.Electrchem,1978,8,333-345
78. 熊宜栋,功率超声在废水处理中的应用,应用声学,2002,21(4),33-36
- 84 -
发表论文和科研情况说明
发表论文和科研情况说明
发表的论文:
[1] 李静, 姚传忠,季民, 厌氧-好氧组合工艺处理制药废水的试验研究,
《工业水处理》,2004 年 1 月
[2] 李 静,季 民 ,周菁, 生物陶粒滤池对微污染原水中不同分子量有机物
的去除,《河北工业大学学报》,2004 年 2 月
参与的科研项目:
教育部天南大合作项目:废水与微污染水处理创新技术研究,2002-
2004。