摘要
目的:
以新型水溶性高分子材料--部分被中和的聚丙烯酸(NP700)为基质,优选止痛贴膏剂的制备工艺,研究贴膏剂的体外透皮释药规律,并初步制定贴膏剂质量标准。
方法:
(1)川芎白芷的提取工艺研究:以欧前胡素和异欧前胡素的提取量为评价指标,考察了不同提取方法对提取的影响;以乙醇浓度、浸泡时间、溶剂倍量为因素,采用星点设计,优选川芎白芷的最佳提取工艺。
(2)花椒细辛提取工艺研究:以挥发油提取量和水溶性成分的出膏率为指标,分别考察了加水量、药材浸泡与否对提取挥油量和水溶性成分出膏率的影响,优选花椒细辛最佳提取工艺。
(3)止痛贴膏剂成型工艺的研究:①以感官指标为评价指标,采用单因素研究空白基质配比,初步筛选出各组成成分的用量范围;②以感官指标和剥离强度为评价指标,采用单因素和正交试验优选止痛贴膏剂最佳配比。
(4)止痛贴膏剂透皮吸收的研究:①以欧前胡素的透过量为指标,考察了不同接受液对促透效果的影响;②考察了不同促渗剂种类和用量对促透效果的影响;③以24h累积释药量为指标,考察了体外透皮给药的释药规律。
(5)止痛贴膏剂质量标准的研究:遵照相关规定,制定了本贴膏剂药物的薄层鉴别方法;建立了贴膏剂中欧前胡素的含量测定方法。
结果:
(1)确定了川芎白芷的最佳提取工艺为:以渗漉法为提取方法,采用86%乙醇、浸泡30h、溶媒用量30倍提取。
(2)确定花椒细辛最佳提取工艺为:采用不浸泡药材直接用8倍于药材的加水量,4个小时提取挥发油及水溶性成分。
(3)确定了处方中主要影响贴膏剂质量的组分的最佳配比为:NP700:甘油:酒石酸:交联剂(Alcl3:Al(OH)3)=2:7.5:0.012:(0.010:0.007);贴剂制备的溶剂为20%乙醇和45%乙醇。
(4)确定了最佳制备工艺:将A(NP700、甘油、氢氧化铝)用磁力搅拌均匀后超声脱气,将D(冰片、氮酮、N甲基砒咯烷酮、挥发油)相加入A相搅拌均匀。将C(川芎白芷提取物、花椒细辛水提物)相混合均匀后,加入A和D相搅拌均匀,超声脱气泡。将B(酒石酸、氯化铝)相混匀后,加入A、D、C相,搅至适当粘度后铺于无纺布上,70℃干燥2小时放冷后,加盖上防粘纸即可。
(5)确定了最佳促渗剂种类和用量为氮酮:N-甲基砒咯烷酮=1:1,用量为处方量的5%。体外释药行为符合威布尔分布函数方程:Q=1.0907t+4.8052r=0.991。
(6)确定了止痛贴膏剂的检查、定性鉴别、含量测定的质量标准草案,每片按欧前胡素计应不低于2mg。
结论:
止痛贴膏剂的制剂工艺可行,质量稳定可靠。NP700适合作为贴膏剂制备的粘合剂。本研究达到了课题设计的预期目的
Objectives
The part of polyacrylic acid (NP700) of the nature and characteristics arestudied as a paste on the new water-soluble polymer materials . To Optimizeextraction and preparation technology for the paste.To study the vitropermeation behavior,and draft quality standards.
Methods
(1)To study Chuanxiong and Baizhi of Extraction of Process: isoimperatorin andpeulustrin of the extraction of indicators as the evaluation to study ofdifferent extraction of methods on the extraction;The Central composite designis used to optimize Chuanxiong and Baizhi’s the best process by usingethanol’s concentration, soaking‘s time, times of solvent as a factors
(2)To study Zanthoxylum and Asarum of Extraction technique : The evaluationof extraction of volatile oil and water-soluble components of the index ratewere used as index to investigate water’s consumption,soak drug or no soak drug forconforming the matter which is water-soluble and volatile oil whether it isaffected. to optimize Zanthoxylum and Asarum of Extraction technique.
(3)To study Paste’s Process of technology:①the total evaluation of senseorgan index was used as index obserbation and single factor observation wasused to screen out the change ranges of main matrix.②The orthogonal designwas applied to optimize the best technology of preparation.
(4)To study of Paste’s percutaneous of absorption:①To use peulustrin in theamount of the indicators studied different acceptation of liquid to affectpermeability②inspected the different infiltration of the amount ofpenetration’senhancement effection③to study of the in vitro release oftransdermal drug delivery by 24h cumulative release of indicators.
(5)To study paste’s quality standards: 2005 edition Pharmacopoeia and relatedliterature is standard to establish this paste’s TLC and Paste method for thedetermination.
Results:
(1) Chuanxiong and Baizhi were extracted by using 86% ethanol of 30 times tosoak 30 h.
(2)The Asarum and the Zanthoxylum were distilled together for volatile oilswith 8-fold water for 4hours.
(3)The best matrix proportion of zhitong Emplastrum showed as polyacry acid(NP700,neutrualized partly)to glycerin to tartaric acid to linking agent(AlCl_3:Al(OH)_3)was 2.1 to 15 to 0.023 to (0.019 to 0.013).
(4)The best paste of preparation was use A ,which was NP700, glycerol, aluminum hydroxide, with uniform magnetic stirring after ultrasound degassing,thenmixed with D which was borneol, Azone,volatile oil,and mixed with C which isChuanxiong,Baizhi extracted,and mixed with B which is tartaric acid andaluminum chloride,then stirred to the appropriate viscosity after resurfacingin the non-woven fabrics, dry 70 degrees after 2 hours Leng,and can be theAnti-Burn Paper.
(5)The equation for in-vitro permeation was Q= 1.0907t+4.8052(r=0.991).
(6) Quality evaluation was performed in line with paste as designated in ChinesePharmacopoeia;besides,qualitative and quantitative method was establishedbased on which a quality standard proposal was drafted(≥2mg peulustrin/perpaste).
Conclusion
The process technology is feasible and stable . NP700 for Paste as a pasteprepared adhesive. Therefor ,the study is successful in achieving itsobjectives.
引文
[1] 刘淑芝,费虹.中药巴布剂研究概况[J].国外医学中医中药分册.1997,19(5):13
[2] 何华,张玉春,焦凯.巴布剂的研究进展.卫生职业教育.2006,1(24):154
[3] 陆晓和,赵仲坤,苏丹. 氮酮对吲哚美辛贴膜透皮吸收的影响[J ] . 中国药科大学学报,1995 ,26 (6) ∶335 - 336.
[4] Roy SD ,Marc G,Flynn GL , et al . Controlled transdermal delivery of fentanyl :characterizations of pressure-sensitive adhesivesfor matrix patchdesign[J ] . J Pharm Sciences ,1996 ,85 (5) ∶491 -495.
[5] Minghetti P ,Cilurzo F ,Casiraghi A. Dermalpatches for the controlledrelease of miconazole :influence of the drug concentration on thetechnological characteristics [ J ] . Drug Dev Ind Pharm ,1999 ,25 (5) ∶679 - 684.
[6] Rafiee-Tehrani M ,Bayat H , Toliat T. Acrylicresins as rate-con-trollingmembranes in propranolol transdermal multilaminatepatch [ J ] . Proc IntSymp Cont rolled Release Bioact Mater ,1997 ,24∶411-412.
[7]Li CH ,Schonfeld E ,Chu T , et al . Transdermal patches comprisingpressure-sensitive polyacrylate adhesive crosslinked withaluminumacetylacetonate and a drug having a reactive aromatichydroxylgroup[ P] . PCT Int . Appl. WO 9640087 A2 ,1996 -12 - 09.
[8] Hashimoto M ,Yoneto K. Flurazepam patches with good bioavailability[ P] .J P 09136835 A2 ,1997 - 05 - 27.
[9] Chol HK. Composition for transdremal delivery system containingnonsteroidal anti-inflammatory drug as an active ingredient [ P ] .Eur. Pat .Appl. EP 0827741 A2 ,1998.
[10] 路芳.透皮吸收制剂及其评价方法.中国实用医学研究杂志,2003,10:589)
[11]朴美兰,张善玉,崔京浩,等 渗透促进剂对紫草素透过大鼠腹部皮肤的作用[J]中国野生植物资源,2003,22(2):39
[12]刘成,胡晋红,朱全刚,等 促渗剂对来氟米特体外经皮渗透的影响[J] 中国药学杂志,2002,37(7):507
[13]刘毅,周冠怀,陈专红 乙醇对丁卡因凝胶透皮和局麻作用的影响[J] 中国临床药理学和治疗学,2003,8(5):522
[14]刘辉,匡长春,汤韧,等 促渗剂对奥沙普秦经皮渗透的促进作用[J] 中国医院药学杂志,2001,21(7):405
[15]黄波,古妙宁,李国锋 盐酸丁丙诺啡凝胶体外透皮渗透实验研究[J] 第一军医大学学报,2002,22(10):895
[16]程怡,高幼衡,虞金宝,等 麝香酮在不同复合促进剂载体中透皮转运的动力学特征[J] 中国中药杂志,2000,25(9):531
[17]Barry BW Lipid-protein-partitioning theory of skin penetration enhancement[J] Controlled Release ,1991,15:237
[18]Hanif Ra ja,Ping Qineng,Liu Guo jie Enhancement effect of geraniol onthe permeation of 5-Fluorou racil through excised rats skin [ J] 中国药科大学学报,1997,28(4):206
[19]王珲,许卫铭,冯小龙 薄荷醇对两种性质化合物体外经兔皮吸收的影响[J] 中国药房,2002,13(3):141
[20] 潘志斌.微针技术的研究进展.中国新药与临床杂志.2005,11:912-915
[21] 刘冉,王晓浩. MEMS 微针阵列及其在生物医学上的应用.[ J ]. 生物医学工程学杂志, 2004, 21 (3) : 482-485.
[22] Ono M ,Akazawa M ,Seki M , et al . External preparation for applicationto the skincontaining lidocaine [P] . Eur Pat Appl ,EP507160 A1 ,1992 ,10,07.
[23] 陆彬.药物新剂型与新技术[M].人民卫生出版社.北京:2005,578-579,568-570
[24] 国家药典委员会.中华人民共和国药典[M].化学工业出版社.2005年版一部,附录9
[25] JIA Wei,XIAO Pei-gen et al.Cataplasma of Traditional ChineseMedicine[J].China Journal of Chinese Materia Medica(中国中药杂志).2003,28(1):9
[26]李瑛,刘舂芳. 试论川芎功用的双向性,江西中医药,2003,34(241):40
[27] 陈友鸿,莫尚志,李洁仪等.川芎挥发油成分研究, 中药材, 2004, 8(27):580
[28] 王文祥, 顾 明, 蒋小岗等.川芎化学成分研究, 中草药,2002,33(1):4
[29] 王义雄,高宣亮,王普善等.川芎中的另一类活性成分[J].中草药.1985.16(11):l7
[30] 李祖伦,杨金蓉,胡荣等.川芎挥发油解热作用及部分机理研究,中医药信息,2003,20(6):31
[31] 彭安,叶红军.川芎嗪诱导 Bel-7402 人肝癌细胞恶性表型逆转的研究[J].临床肝胆病杂志,2002,l8(3):157—8
[32] 舒冰,周重建,马迎辉等,中药川芎中有效成分的药理作用研究进展,中国药理学通报, 2006,22(9):1043
[33] 张婷,川芎嗪对脑组织的保护作用,中华医学研究杂志,2006,6(9):994
[34] 胡益勇, 徐晓玉.阿魏酸的化学和药理研究进展,中成药,2006,28(2):253
[35] 夏黎明,姚成. 中药白芷的研究现状, 中医药研究,2002,18(5):56
[36] 康学军,曲见松,顾忠泽.白芷多糖的分析, 分析化学研究简报,2006,34(6):533
[37] 刘红梅, 张明贤, 刘杨平等. 超临界 CO2 萃取白芷中香豆素类成分的工艺优化研究, 中成药,2004.26(2):90
[38] 刘红梅. 均匀设计优选微波辅助萃取白芷香豆素类成分, 华西药学杂志, 2O04,19(3):193
[39] 王梦月, 贾敏如,马逾英等.白芷总香豆素的药理作用研究,时珍国医国药,2005,16(10):954
[40] 聂 红,沈映君,吴俊梅等. 白芷挥发油镇痛、镇静作用和身体依赖性研究, 中药新药与临床药理,2002,13(4):221
[41] 王春梅,崔新颖,李贺. 白芷香豆素的抗炎作用研究, 北华大学学报,2006,7(4):318
[42] 戴宇.白芷的研究进展,中国药业,2001,10(9):61
[43] 陈超.郑卫红.熊素兵.等.细辛与 verapamil 镇痛协同作用的实验研究.中国药理学通报 2003;19(3):33
[44] 黄顺旺. 细辛的药理毒理和临床应用. 安徽医药,2003:12;7(6):477
[45] 周勇,姚三桃,吴琦,等.细辛挥发油抗真茵作用及其有效成分黄樟醚的研究.中医杂志 1981:22(12):62
[46] 张明发,沈雅琴,朱自平,等.花椒温中止痛药理研究[J].中国中药杂志,1991,16:49
[47] 许青嫒.花椒粗提物对应激性心脏损伤的保护作用[J].中草药,1993.24(5):2
[48] 吴伟,崔光华.星点设计-效应面优化法及其在药学中的应用.国外医学药学分册,2000,10:292-298
[49] 陆彬.药物新剂型与新技术[M].人民卫生出版社.北京:2005,38
[50] 刘继勇,田景振,胡晋红.痹痛宁透皮贴剂体外释放度测定.中国医院药学杂志,2003,23(12):712.
[51] 许英爱,戈延茹,王雅君等.复方骨质增生贴剂体外透皮速率测定和体外释放研究.中成药,2001,4:237-240.