摘要
采用嗜酸性硫杆菌生物淋滤联合Fenton氧化法对印染污泥脱水性能进行了研究。结果表明,生物淋滤过程中pH下降速率随着硫粉添加量增加而变快,经生物淋滤处理后污泥的脱水性能在一定程度上得到了改善。对生物淋滤后的污泥进行了Fenton氧化处理,获得的最佳反应条件为反应时间2 h,H2O2和Fe2+添加量分别为6 g/L和0.5 g/L。在该条件下,污泥上清液中总有机碳(TOC)由20.8 mg/L增加到356.6 mg/L;污泥比阻(SRF)和滤饼含水率分别由5.98×1011s2/g和88.75%减少至1.26×1011s2/g和82.85%。生物淋滤-Fenton氧化法在污泥破解程度和脱水性能改善方面均优于单独Fenton氧化法。
Bioleaching combined with Fenton oxidation was used to investigate dewaterability of textile dyeing sludge. The results showed that with the use of acidophilic thiobacilli during sludge bioleaching,pH decreased quickly with the increase of sulfur dosage and sludge dewaterability was enhanced to some extent by bioleaching. The optimal experimental conditions for bioleaching-Fenton oxidation of the textile dyeing sludge were as follows: reaction time of 2 h,H2O2dosage of 6 g / L and Fe2 +dosage of 0. 5 g / L. Under these conditions,the values of total organic carbon( TOC) in the supernatant increased from 20. 8 mg / L to 356. 6 mg / L; and specific resistance to filtration( SRF) and moisture of sludge cake decreased from 5. 98 × 1011s2/ g and 88. 51% to 1. 26 × 1011s2/ g and 82. 85%,respectively. Bioleaching-Fenton oxidation showed more advantages in sludge disruption and dewaterability over single Fenton oxidation.
引文
[1]朱虹.印染废水生物处理中剩余污泥减量化技术研究.上海:东华大学博士学位论文,2005Zhu Hong.Study on residual sludge reducing from dyeing and printing wastewater biological treatment.Shanghai:Doctor Dissertation of Donghua University,2005(in Chinese)
[2]何文远,杨海真,顾国维.酸处理对活性污泥脱水性能的影响及其作用机理.环境污染与防治,2006,28(9):680-682He yuanwen,Yang Haizhen,Gu guowei.Acid treatment of waste activated sludge for better dewaterability.Environmental Pollution and Control,2006,28(9):680-68(in Chinese)
[3]Neyens E.,Baeyens J.A review of classic Fenton’s peroxidation as an advanced oxidation technique.Journal of Hazardous Materials,2003,98(1-3):33-50
[4]Buyukkamaci N.Biological sludge conditioning by Fenton’s reagent.Process Biochemistry,2004,39(11):1503-1506
[5]陈英文,刘明庆,惠祖刚,等.Fenton氧化破解剩余污泥的实验研究.环境工程学报,2011,5(2):409-413Chen Yingwen,Liu Mingqing,Hui Zugang,et al.Experimental study on excess sludge disintegration by Fenton oxidation.Chinese Journal of Environmental Engineering,2011,5(2):409-413(in Chinese)
[6]Neyens E.,Baeyens J.,Dewil R.Advanced sludge treatment affects extracellular polymeric substances to improve activated sludge dewatering.Journal of Hazardous Materials,2004,106(2-3):83-92
[7]Lu M.,Lin C.,Liao C.,et al.Dewatering of activated sludge by Fenton’s reagent.Advances in Environmental Research,2003,7(3):667-670
[8]Zhou L.X.,Fang D.,Wang S.M.,et al.Bioleaching of Cr from tannery sludge:The effects of initial acid addition and recycling of acidified bioleached sludge.Environmental Technology,2005,26(3):277-284
[9]郑冠宇,王世梅,周立祥.污泥生物沥浸处理对病原物的杀灭效果影响.环境科学,2007,28(7):1539-1542Zheng Guanyu,Wang Shimei,Zhou Lixiang.Elimination of pathogens in municipal sludge and tannery sludge by bioleaching approach.Environmental Science,2007,28(7):1539-1542(in Chinese)
[10]Tyagi R.D.,Sreekrishnan T.R.,Blais J.F.,et al.Effect of dissolved oxygen on sludge acidification during the SSDML process.Water,Air,and Soil Pollution,1998,102(1):139-155
[11]宋兴伟,周立祥.生物沥浸处理对城市污泥脱水性能的影响研究.环境科学学报,2008,28(10):2012-2017Song Xingwei,Zhou Lixiang.The influence of bioleaching on dewaterability of municipal sewage sludge.Acta Scientiae Circumstantiae,2008,28(10):2012-2017(in Chinese)
[12]刘奋武,周立祥.不同能源物质配合及化学强化对生物沥浸法提高城市污泥脱水性能的效果.环境科学学报,2009,29(5):974-979Liu Fenwu,Zhou Lixiang.Enhancing dewaterability of municipal sewage sludge through the combined approaches of bioleaching and Fenton reaction.Acta Scientiae Circumstantiae,2009,29(5):974-979(in Chinese)
[13]Zhang P.,Zhu Y.,Zhang G.,et al.Sewage sludge bioleaching by indigenous sulfur-oxidizing bacteria:Effects of ratio of substrate dosage to solid content.Bioresource Technology,2009,100(3):1394-1398
[14]Dignac,M.F.,Urbain V.,Rybacki D.,et al.Chemical description of extrallular polymers:Implication on activated sludge floc structure.Water Science&Technology,1998,38(8-9):45-53
[15]刘昌庚,张盼月,曾光明,等.生物淋滤-PAC与PAM联合调理城市污泥.环境科学,2010,31(9):2124-2128Liu Changgeng,Zhang Panyue,Zeng Guangming,et al.Sewage sludge conditioning by bioleaching-dual PAC and PAM addition.Environmental Science,2010,31(9):2124-2128(in Chinese)
[16]方迪,周立祥.固体浓度对生物淋滤法去除制革污泥中铬的影响.中国环境科学,2004,24(2):163-165Fang Di,Zhou Lixiang.The influence of solid concentration on the removal of Cr from tannery sludge by bioleaching technique.China Environmental Science,2004,24(2):163-165(in Chinese)
[17]刘云国,肖鑫,李欣,等.土著微生物对尾矿中重金属的淋滤研究.湖南大学学报(自然科学版),2011,38(2):70-74Liu Yunguo,Xiao Xin,Li Xin,et al.Bioleaching of heavy metals from mine tailings by indigenous microorganisms.Journal of Hunan University(Natural Sciences),2011,38(2):70-74(in Chinese)
[18]Chen S.Y.,Chiu Y.C.,Chang P.L.,et a1.Assessment of recoverable form of sulfur particles used in bioleaching of contaminated sediments.Water Research,2003,37(2):450-458
[19]潘胜,黄光团,谭学军,等.Fenton试剂对剩余污泥脱水性能的改善.净水技术,2012,31(3):26-31Pan Sheng,Huang Guangtuan,Tan Xuejun,et al.Improvement of excess sludge dewatering performance with Fenton reagent.Water Purification Technology,2012,31(3):26-31(in Chinese)
[20]周煜,张爱菊,张盼月,等.光-Fenton氧化破解剩余污泥和改善污泥脱水性能.环境工程学报,2011,5(11):2600-2604Zhou Yu,Zhang Aiju,Zhang Panyue,et al.Sewage sludge disintegration and dewaterability improvement by photoFenton oxidation.Chinese Journal of Environmental Engineering,2011,5(11):2600-2604(in Chinese)
[21]陈传好,谢波,任源,等.Fenton试剂处理废水中各影响因子的作用机制.环境科学,2000,21(3):93-96Chen Chuanhao,Xie Bo,Ren Yuan,et al.The mechanisms of affecting factors in treating wastewater by Fenton reagent.Environmental Science,2000,21(3):93-96(in Chinese)
