摘要
为解决低碳氮比有机废水生物脱氮的难题,经济高效的厌氧氨氧化(ANAMMOX)技术得到广泛研究,但ANAMMOX菌群对环境要求苛刻且富集困难,系统启动缓慢,限制了其工程应用.前期研究中,构建了用于处理高氨氮低碳氮比养猪废水的升流式限氧生物膜反应器(UOLBR),经180 d的启动运行实现了以ANAMMOX为主导的脱氮功能.将UOLBR闲置2个月,以COD与TN比为0. 6～1. 0的干清粪养猪废水为进水,在水力停留时间10 h、25℃和出水回流比25∶1的条件下再次启动,考察其处理效果和ANAMMOX功能的恢复情况.结果表明,经过溶解氧分别为2. 5～3. 0和0. 2～0. 5 mg/L两个阶段,共计53 d的连续运行,UOLBR的处理效能得以恢复并达到稳定状态,对COD、NH_4~+-N、TN的平均去除率分别为64. 0%,96. 5%和91. 7%,出水质量浓度分别仅为61,7. 0和16. 4 mg/L左右.微生物群落结构和物料平衡分析表明,UOLBR系统恢复了以ANAMMOX为主要脱氮途径的特征.该研究可为低碳氮比有机废水ANAMMOX处理系统的启动和运行管理提供指导.
Anaerobic ammonium oxidation( ANAMMOX) is known as the most effective process for nitrogen removal from organic wastewater with low ratio of carbon to nitrogen. But ANAMMOX population is difficult to enrich and sensitive to environment change,which results in a long start-up process. Thus,the tardy start-up of ANAMMOX process is a major issue for engineering application. In preliminary research,an upflow oxygen limitation biofilm reactor( UOLBR) was constructed to treat piggery wastewater with high ammonium( NH_4~+-N)and low C/N ratio. After the 180-day start-up process,an excellent synchronous removal of chemical oxygen demand( COD) and total nitrogen( TN) was achieved with ANAMMOX as the dominant nitrogen removal pathway.Idled for 2 months,the UOLBR was restarted at 25 ℃ with a hydraulic retention time of 10 h and an effluent reflux ratio of 25∶ 1. Fed with manure-free piggery wastewater with the COD/TN ratio of 0. 6-1. 0,performance of the UOLBR during the restart-up process was evaluated. Operation process of the reactor was divided into 2 stages with a dissolved oxygen of 2. 5-3. 0 and 0. 2-0. 5 mg/L,respectively. The results showed that the UOLBR could recover from the idle state and a new steady state was reached within 53 days. Within the steady phase,the removal rates of COD,NH_4~+-N,and TN in the reactor averaged 63. 96%,96. 5% and 91. 7%,with residues of about 61,7. 0 and 16. 4 mg/L in the effluent,respectively. Analysis of microbial community along with mass balance indicated that the recovered UOLBR was again characterized by ANAMMOX as the dominant approach for nitrogen removal from the wastewater. This work would be helpful for the start-up and management of ANAMMOX processes.
引文
[1]OTHMAN I,ANUAR A N,UJANG Z,et al. Livestock wastewater treatment using aerobic granular sludge[J]. Bioresource Technology,2013,133:630. DOI:10. 101 6/j. biortech. 2013. 01. 149
[2]KUMAR M,LEE P Y,FUKUSIHMA T,et al. Effect of supplementary carbon addition in the treatment of low C/N high-technology industrial wastewater by MBR[J]. Bioresource Technology,2012,113:148. DOI:10. 1016/j. biortech. 2011. 12. 102
[3]DU Rui,CAO Shenbin,WANG Shuying,et al. Performance of partial denitrification(PD)-ANAMMOX process in simultaneously treating nitrate and low C/N domestic wastewater at low temperature[J]. Bioresource Technology,2016,219:420. DOI:10. 1016/j.biortech. 2016. 07. 101
[4] HUANG Haiming, CHEN Yongqiang, JIANG Yang, et al.Treatment of swine wastewater combined with Mg O-saponification wastewater by struvite precipitation technology[J]. Chemical Engineering Journal,2014,254:418. DOI:10. 1016/j. cej. 201 4.05. 054
[5]VAN D U,JETTEN M,VAN L M. The SHARON-Anammox process for treatment of ammonium rich wastewater[J]. Water Science and Technology:A Journal of the International Association on Water Pollution Research,2001,44(1):153
[6]STROUS M,HEIJNEN J J,KUENEN J G,et al. The sequencing batch reactor as a powerful tool for the study of slowly growing anaerobic ammonium-oxidizing microorganisms[J]. Applied Microbiology and Biotechnology,1998,50(5):589. DOI:10.1007/s002530051340
[7]LING Jian,CHEN Shulin. Impact of organic carbon on nitrification performance of different biofilters[J]. Aquacultural Engineering,2005,33(2):150. DOI:10. 1016/j. aquaeng. 2004. 12. 002
[8]NI Shouqing,NI Jianyuan,HU Deliang,et al. Effect of organic matter on the performance of granular anammox process[J].Bioresource Technology, 2012, 110:701. DOI:10. 1016/j.biortech. 2012. 01. 066
[9]CHU Zhaorui,WANG Ke,LI Xiangkun,et al. Microbial characterization of aggregates within a one-stage nitritation-anammox system using high-throughput amplicon sequencing[J]. Chemical Engineering Journal,2015,262:41. DOI:10. 1016/j. cej. 2014. 09. 067
[10]WANG Jianlong,YANG Ning. Partial nitrification under limited dissolved oxygen conditions[J]. Process Biochemistry,2004,39(10):1223. DOI:10. 1016/S0032-9592(3)00249-8
[11]ZHENG Shaokui,LI Huijun,CUI Cancan. An upflow microaerobic sludge blanket reactor operating at high organic loading and low dissolved oxygen levels[J]. Biotechnology Letters,2011,33(4):693. DOI:10. 1007/s10529-010-0505-4
[12]NIU Tianhao,ZHOU Zhen,SHEN Xuelian,et al. Effects of dissolved oxygen on performance and microbial community structure in a micro-aerobic hydrolysis sludge in situ reduction process[J].Water Research,2016,90:369. DOI:10. 1016/j. watres. 2015.12. 050
[13]王成,孟佳,李玖龄,等.升流式微氧生物膜反应器处理高氨氮低碳氮比养猪废水的效能[J].化工学报,2016,67(9):3895WANG Cheng,MENG Jia,LI Jiuling,et al. Pollutant removal efficiency in upflow microaerobic biofilm reactor treating manure-free piggery wastewater with low COD/TN ratio and high NH+4-N[J].CIESC Journal,2016,67(9):3895
[14]ELAWWAD A,SANDNER H,KAPPELMEYER U,et al. Long term starvation and subsequent recovery of nitrifiers in aerated submerged fixed bed biofilm reactors[J]. Environmental Technology,2013,34(8):945. DOI:10. 1080/09593330. 2012.722758
[15]YILMAZ G,LEMAIRER R,KELLER J,et al. Effectiveness of an alternating aerobic, anoxic/anaerobic strategy for maintaining biomass activity of BNR sludge during long-term starvation[J].Water Research,2007,41(12):2590. DOI:10. 1016/j. watres.2007. 02. 011
[16]LI Jianzheng,MENG Jia,LI Jiuling,et al. The effect and biological mechanism of COD/TN ratio on nitrogen removal in a novel upflow microaerobic sludge reactor treating manure-free piggery wastewater[J]. Bioresource Technology,2016,209:360. DOI:10. 1016/j.biortech. 2016. 03. 008
[17]何佳敏,孟佳,张永,等.温度降低对UMSR处理高氨氮低碳氮比养猪废水效能的影响[J].化工学报,2017,68(5):2074HE Jiamin,MENG Jia,ZHANG Yong,et al. Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH+4-N and low COD/TN ratio[J]. CIESC Journal,2017,68(5):2074
[18]国家环境保护总局.水和废水监测分析方法[M]. 4版.北京:中国环境科学出版社,2006Ministry of Environmental Protection. Detection and analysis method of water and wastewater[M]. 4th ed. Beijing:China Environment Science Press,2006
[19]MENG Jia,LI Jiuling,LI Jianzheng,et al. Effect of reflux ratio on nitrogen removal in a novel upflow microaerobic sludge reactor treating piggery wastewater with high ammonium and low COD/TN ratio:Efficiency and quantitative molecular mechanism[J].Bioresource Technology, 2017, 243:922. DOI:10. 1016/j.biortech. 2017. 07. 052
[20]MENG Jia,LI Jiuling,LI Jianzheng,et al. Nitrogen removal from low COD/TN ratio manure-free piggery wastewater within an upflow microaerobic sludge reactor[J]. Bioresource Technology,2015,198:884. DOI:10. 1016/j. biortech. 2015. 09. 023
[21]汪瑶琪,张敏,姜滢,等.厌氧氨氧化启动过程及微生物群落结构特征[J].环境科学,2017,38(12):5184WANG Yaoqi,ZHANG Min,JIANG Ying,et al. Start-up and characteristics of microbial community structure of ANAMMOX[J].Environmental Science,2017,38(12):5184
[22]IGARASHI N,MORIYAMA H,FUJIWARA T,et al. The 2. 8angstrom structure of hydroxylamine oxidoreductase from a nitrifying chemoautotrophic bacterium,Nitrosomonas europaea[J]. Nature Structural and Molecular Biology,1997,4(4):276. DOI:10.1038/nsb0497-276
[23]GONZALEZ M A,RODRIGUEZ S A,GARCIA R M J,et al.Performance and bacterial community dynamics of a CANON bioreactor acclimated from high to low operational temperatures[J].Chemical Engineering Journal,2016,287:557. DOI:10. 1016/j.cej. 2015. 11. 081
[24]ZHENG Xuesong,YANG Hong,LI Daotang. Change of microbial populations in a suspended-sludge reactor performing completely autotrophic N-removal[J]. World Journal of Microbiology and Biotechnology,2005,21(6/7):843. DOI:10. 1007/s11274-004-5956-0
[25]BOON B,LAUDELOUT H. Kinetics of nitrite oxidation by Nitrobacter winogradskyi[J]. Biochemical Journal,1962,85(3):440. DOI:10. 1042/bj0850440
[26]DAIMS H,NIELSEN P,NIELSEN J,et al. Novel Nitrospira-like bacteria as dominant nitrite-oxidizers in biofilmsfrom wastewater treatment plants:Diversity and in situ physiology[J]. Water Science and Technology,2000,41(4/5):85
[27]SONG B,KERKHOF L J,HAGGBIOM M M. Characterization of bacterial consortia capable of degrading 4-chlorobenzoate and 4-bromobenzoate under denitrifying conditions[J]. FEMS Microbiology Letters,2002,213(2):183. DOI:10. 1016/S0378-1097(2)00804-2
[28]ROSSI F,MOTTA O,MATRELLA S,et al. Nitrate removal from wastewater through biological denitrification with OGA 24 in a batch reactor[J]. Water,2015,7(1):51. DOI:10. 3390/w7010051
[29]LI Enchao,WANG Rongchang,JIN Xuewen,et al. Investigation into the nitrate removal efficiency and microbial communities in a sequencing batch reactor treating reverse osmosis concentrate produced by a coking wastewater treatment plant[J].Environmental Technology,2017:1. DOI:10. 1080/09593330.2017. 13 52036
[30] TUAN M N, KIM J. Azohydromonas riparia sp. nov. and Azohydromonas ureilytica sp. nov. isolated from a riverside soil in South Korea[J]. Journal of Microbiology,2017,55(5):330.DOI:10. 1007/s12275-017-6519-z
[31]SAMPAIO D S,BARBOZA A J R,DE JESUS H E,et al.Distribution of anaerobic hydrocarbon-degrading bacteria in soils from King George Island,Maritime Antarctica[J]. Microbial Ecology,2017,74(4):810. DOI:10. 1007/s00248-017-0973-3
[32]ZHANG Lili,ZHANG Chao,HU Chengzhi,et al. Sulfur-based mixotrophic denitrification corresponding to different electron donors and microbial profiling in anoxic fluidized-bed membrane bioreactors[J]. Water Research,2015,85:422. DOI:10. 1016/j. watres. 2015. 08. 055
[33]GUO Jianhua,PENG Yongzhen,FAN Lu,et al. Metagenomic analysis of anammox communities in three different microbial aggregates[J]. Environmental Microbiology,2016,18(9):2979.DOI:10. 1111/1462-2920. 13132
[34]SLOBODKINA G B,KOVALEVA O L,MIROSHNICHENKO M L,et al. Thermogutta terrifontis gen. nov.,sp. nov. and Thermogutta hypogea sp. nov.,thermophilic anaerobic representatives of the phylum Planctomycetes[J]. International Journal of Systematic and Evolutionary Microbiology,2015,65:760. DOI:10. 1099/ijs. 0. 000009
[35]DONG Qian,LIU Yanchen,SHI Hanchang,et al. Effects of graphite nanoparticles on nitrification in an activated sludge system[J]. Chemosphere,2017,182:231. DOI:10. 1016/j. chemosphere.2017. 04. 144
[36]MENG Jia,LI Jiuling,LI Jianzheng,et al. Enhanced nitrogen removal from piggery wastewater with high NH+4and low COD/TN ratio in a novel upflow microaerobic biofilm reactor[J]. Bioresource Technology,2018,249:935
[37]邓凯文,李建政,赵博玮. WFSI处理低碳氮比养猪废水的效果及脱氮机制[J].中国环境科学,2016,36(1):87DENG Kaiwen, LI Jianzheng, ZHAO Bowei. Efficiency and denitrification mechanism in a wood-chip-framework soil infiltrator treating piggery wastewater with low C/N ratio[J]. China Environmental Science,2016,36(1):87
